Engine

The rocker assembly, including hydraulic followers, inlet and exhaust valves [not burnt valves], springs and guides, cylinder head [not cracked and de-coking], cylinder head gasket [except skim], push rods, camshaft and followers, timing gears and chains [excluding tensioner], oil pump, pistons and rings, cylinder bores, con rods, gudgeon pins and bearings, crankshaft and bearings, inlet manifold, flywheel and ring gear. timing belts are covered providing that the last due change of belt has taken place as specified by the manufacturer's schedule [proof required].

Manual Gearbox

Internal gears, synchromesh hubs, selectors, shafts bearing and bushes and transfer gears.

Automatic Gearbox

Internal shafts, gears clutches, brake bands, valve block, governor, oil pump, bearing and bushes, servo, drive plate and transfer gears.

Torque Converter

Failure of any internal mechanical parts.

Continuously Variable Transmission [CTX]

Internal clutches, planetary gears, reduction gears, shafts, variable pulleys, thrust link drives, internal seals, bushes and bearings.

Differential

Internal crown wheel and pinion, gears, shafts, bearings and bushes, thrust washers and spacers.

Clutch

Centre plate, pressure plate, release bearing, oil contamination [centre plate only], and master and slave cylinders.

Front-Wheel Drive

Drive shafts, including constant velocity joints, universal joints and couplings [not gaiters].

Wheel Bearings

front and rear wheel bearings.

Propshaft

Universal joints and couplings.

Rear-Wheel Drive

Half shafts, rear-wheel external drive shafts, including constant velocity joints, universal joints and couplings [not gaiters].

Four-Wheel Drive

All four-wheel drive components are covered if the extra premium has been paid [see proposal form].

Fuel System [Diesel & Petrol]

Carburettors, automatic choke, lift pump, mechanical or electrical fuel pumps and tank sender unit.

Fuel Injection System

Throttle body, airflow meter, idle control valve, cold start valve, warm up regulator, overrun cut off valve, throttle potentiometer, fuel accumulator, pressure regulator, map sensor [except injectors and heater plugs].

Engine Cooling System

Radiator, oil cooler, heater matrix, water pump, viscous fan coupling, thermostat and thermostat housing.

Air Conditioning [Factory Fitted]

the air conditioning compressor unit is covered if you have paid the extra premium [see proposal form].

Steering [Including Power Assisted Streeing]

Steering rack and pinion [not gaiters], steering box, power steering rack and pump, power steering reservoir and idler box.

Turbo Charger [Factory Fitted]

The turbo charger unit is covered only if agreed and if the extra premium has been paid [see proposal form].

Front & Rear Suspension

Hydrolastic displacers and hydropneumatic spheres, coil springs, upper and lower wishbones and ball and swivel joints.

Brakes

Brake master cylinder, wheel cylinders, restrictor valve, brake caliper seals and servo.

Anti Locking Brake System [ABS] [Factory Fitted]

Providing the additional premium has been paid the ABS modulator and sensors will be covered [see proposal form].

Electrical System

Starter motor and solenoid, including pre-engagement mechanism and bendix drive, alternator/diode pack, coil voltage regulator, window and sun roof motors, electric window switches, sunroof switch, centralised locking, heater fan motor, indicator flasher relay, distributor, front and rear windscreen wiper and washer motors, electronic ignition amplifier, thermostatically-controlled radiator fan motor, horn and multi-function stalk switch.

Engine Management [ECU]

Engine electronic control unit.

Working Materials

Oils, oil filter and anti-freeze are covered only if it is essential to replace them because of the failure of a part which is covered under this policy.

Casings

If any of the covered parts fail and this damages the casing, it will also be covered.